A EZGO gas golf cart will not go in reverse if there is a faulty transmission system, improper cable adjustment, a defective microswitch present inside the Forward/Reverse controller, or a malfunctioning neutral limit switch. Sort By: Featured Items. Long with EZGO shifters, you'll also find golf cart cam switch replacements, mounting brackets, or even the forward and reverse switch shaft. Replace it if needed. As a matter of fact, you'll even find the EZGO Medalist and TXT Forward DCS Micro Switch. Interchange the big cables behind the F/R switch that are at 9 o'clock and 3 o'clock positions and see if the problem persists. Rear Axle and Suspension. They should be tight and secure without corrosion. Our extensive selections extend to every EZGO part and accessory you might need.
© 2021 Performance Plus Carts, All Rights Reserved. Check out for a defective controller and if you notice that it isn't functioning as it should, it's time to get a new one in place of the old controller. Inspect the ignition switch to check if it's working. If you're able to do this, the problem is with your transmission system. Check for a faulty controller by unplugging the J4 cable from it and measuring the voltage rating at its pins 1 and 2. This is a good chance to check if the tab on the key switch has become loose. Look out for a defective solenoid. Shop All Replacement Parts. Search Keyword: Search. Fuel Pumps and Fuel Parts. Why EZGO gas golf cart won't go forward? Shop All Charging & Performance. Club Car Golf Cart DS/Precedent 48-Volt Forward/Reverse Switch (Fits 1996-Up).
Club Car DS Gas Golf Cart Transmission Forward Reverse Cable Fits 1984 to 1997. Why EZGO PDS will not go in reverse. A EZGO PDS golf cart may go forward but not in the reverse direction if the Forward/Reverse switch has loose connections or the controller has gone bad. Additionally, we have a nationwide network of warehouses, so shipping is quick and convenient. Why EZGO gas golf cart will not reverse? Inspect the cable terminals of the batteries for corrosion. Take off the outer snap ring from the axle tube, - Fit a slide hammer to the axle shaft thread and take off the axle and bearing from the axle tube, - Take off the bearing ensuring you support the bearing inner race on an arbor press bed, - Put force to the threaded end of the axle shaft. Fits STAR Golf Carts 2009 & up.
Give Us A Call (800) 539-3830. Loose or corroded cable connections. Is there any way I can change the gears like newer carts you can swap gears all the way up to 6:1? You can try the steps highlighted here to fix the problem. Electric Motors and Parts. Checking the Lubricant Level.
If it fails, replace the controller with a better quality one rather than repairing the old one. However, if they show signs of wear and tear, you must get them replaced. All front spring hardware should be torqued to 21-25ft. Try bypassing the neutral limiter switch. It's best to get the whole accelerator setup replaced. Look out for a failing motor brake.
Check all the cables and ensure that their connections are firm, tight, and securely in space. EZGO Marathon goes forward but not reverse. Improperly functioning solenoid. Gas & Electric Performance Upgrades. If they are corroded, you'll have to clean them or sometimes even get them changed.
Malfunctioning microswitch. Rear Suspension General. You can check out the steps given below to address this problem.